right the burger has a little oil leak witch has been seen too by the main dealer under the warranty. all good.
no they found oil coming from the join in the crank case and changed the seals all round, but it seams to still be there now this leak only happens if i take it for a run at 70 mph for any length of time. now due to belt wear its running at 8000rpm to hit a true sat nav 70 mph when im pottering around at 50/60 mph its fine dry as a bone. now there is no oil in the airbox at all. and its got both me and the dealer at a loss. can any of you guys shed any light on this? if so maybe you wonna try opening a suzuki main dealer
thanks peeps
dam oil leak
- amsmtb
- Benefactor
- Posts: 115
- Joined: Wed Sep 30, 2009 6:14 am
- Current Ride: Suzuki burgman 400za l4
- Location: ipswich suffolk
- Contact:
dam oil leak
Suzuki burgman 400za l4
Suzuki burgman 400 k5
Gilara nexus 500 2004
Suzuki Burgman AN400 k7 2006
Piaggio x7 125 2010
Yamaha Majesty YP125R 2000
jinun db50qt6 (NInja) 2007
Honda nsr125k JC20 1991
Suzuki burgman 400 k5
Gilara nexus 500 2004
Suzuki Burgman AN400 k7 2006
Piaggio x7 125 2010
Yamaha Majesty YP125R 2000
jinun db50qt6 (NInja) 2007
Honda nsr125k JC20 1991
- TmaX9
- Posts: 633
- Joined: Thu Apr 09, 2009 5:15 pm
- Current Ride: 04 and 54 X9 500 Evos
- Location: Fylde Coast Lancashire
Re: dam oil leak
Not knowing specifically about burgers, but the Piaggio motors have a small reed valve in the engine cover over the crankcase breather. If this gets stuck it may prevent the breather from functioning. Excessive crankcase pressure will then look for an alternative exit via the weakest gasket.
Test to see if the breather pipe is blocked or has got nipped somehow.
A little dampness in the air box is normal, totally dry is unusual.
which joint is leaking, the main crankcase halves, or the one to the flywheel?
Test to see if the breather pipe is blocked or has got nipped somehow.
A little dampness in the air box is normal, totally dry is unusual.
which joint is leaking, the main crankcase halves, or the one to the flywheel?
- mightbesane
- Benefactor
- Posts: 287
- Joined: Thu Aug 18, 2011 1:41 pm
- Current Ride: Burgman 400 K4
- Location: Lehigh Valley, PA/Languedoc, France
Re: dam oil leak
Also check the breather hose (and others while you're at it) for integrity. My Burger is a little older, but when we went through it after I bought it, we found dry rot prevalent.
- amsmtb
- Benefactor
- Posts: 115
- Joined: Wed Sep 30, 2009 6:14 am
- Current Ride: Suzuki burgman 400za l4
- Location: ipswich suffolk
- Contact:
Re: dam oil leak
It's define coming from the join in the crank case just behind the rear wheel. Maybe a blocked breather?
Suzuki burgman 400za l4
Suzuki burgman 400 k5
Gilara nexus 500 2004
Suzuki Burgman AN400 k7 2006
Piaggio x7 125 2010
Yamaha Majesty YP125R 2000
jinun db50qt6 (NInja) 2007
Honda nsr125k JC20 1991
Suzuki burgman 400 k5
Gilara nexus 500 2004
Suzuki Burgman AN400 k7 2006
Piaggio x7 125 2010
Yamaha Majesty YP125R 2000
jinun db50qt6 (NInja) 2007
Honda nsr125k JC20 1991
- TmaX9
- Posts: 633
- Joined: Thu Apr 09, 2009 5:15 pm
- Current Ride: 04 and 54 X9 500 Evos
- Location: Fylde Coast Lancashire
Re: dam oil leak
There is no oil way or gallery between crankcase halves so it's a straight forward leak caused by internal pressure, unless there is an inherent fault in the casting where someone has been wedging the halves apart with a screwdriver!
Are you sure the dealer properly attempted a repair by splitting the crankcase and re-sealing the joint, or did they just smear some Hermatite over the joint and hope you would go away?
Even if the fault is caused by a blocked breather, the crankcase joint is the last place you want to see a leak coming from as it's a major job to fix. Engine out, barrel off transmission removed....
Are you sure the dealer properly attempted a repair by splitting the crankcase and re-sealing the joint, or did they just smear some Hermatite over the joint and hope you would go away?
Even if the fault is caused by a blocked breather, the crankcase joint is the last place you want to see a leak coming from as it's a major job to fix. Engine out, barrel off transmission removed....
- amsmtb
- Benefactor
- Posts: 115
- Joined: Wed Sep 30, 2009 6:14 am
- Current Ride: Suzuki burgman 400za l4
- Location: ipswich suffolk
- Contact:
Re: dam oil leak
Im sad too say it is but sad for orwell motor cycles of Ipswich as it is there problem to fix not mine they sold it to me like it as its leeked from day one but werrenty should take care of that.TmaX9 wrote:There is no oil way or gallery between crankcase halves so it's a straight forward leak caused by internal pressure, unless there is an inherent fault in the casting where someone has been wedging the halves apart with a screwdriver!
Are you sure the dealer properly attempted a repair by splitting the crankcase and re-sealing the joint, or did they just smear some Hermatite over the joint and hope you would go away?
Even if the fault is caused by a blocked breather, the crankcase joint is the last place you want to see a leak coming from as it's a major job to fix. Engine out, barrel off transmission removed....
Suzuki burgman 400za l4
Suzuki burgman 400 k5
Gilara nexus 500 2004
Suzuki Burgman AN400 k7 2006
Piaggio x7 125 2010
Yamaha Majesty YP125R 2000
jinun db50qt6 (NInja) 2007
Honda nsr125k JC20 1991
Suzuki burgman 400 k5
Gilara nexus 500 2004
Suzuki Burgman AN400 k7 2006
Piaggio x7 125 2010
Yamaha Majesty YP125R 2000
jinun db50qt6 (NInja) 2007
Honda nsr125k JC20 1991